Energy, Exergy, and Economic Analyses and Optimization of Solar Organic Rankine Cycle with Multi-objective Particle Swarm Algorithm | ||
| Renewable Energy Research and Applications | ||
| دوره 2، شماره 1، فروردین 2021، صفحه 9-23 اصل مقاله (983.21 K) | ||
| نوع مقاله: Original Article | ||
| شناسه دیجیتال (DOI): 10.22044/rera.2020.9998.1038 | ||
| نویسندگان | ||
| A. Beiranvand1؛ M.A. Ehyaei* 1؛ A. Ahmadi2؛ Jose Luz Silvaria3 | ||
| 1Department of Mechanical Engineering, Pardis Branch, Islamic Azad University, Pardis New City, Iran. | ||
| 2School of New Technologies, Iran University of Science & Technology, Islamic Republic of Iran. | ||
| 3Sao Paulo State University, UNESP, FEG, Energy Department, Brazil | ||
| چکیده | ||
| The high potential of solar energy in Iran, as well as the problem of air pollution, makes it increasingly inevitable that solar energy is used. In this study, the solar-powered Organic Rankine cycle (ORC) has been investigated. The solar-type collector is a flat plate collector. The energy, exergy, and economic analyses of the hybrid system with the MOPSO algorithm have been carried out for Tehran., the capital of Iran. The working fluid of the solar collector has assumed water and the working fluid of the ORC cycle is R123. The MATLAB software is used for simulation and to compute the R123 fluid properties, the Refprop software is used. The exergy investigation shows that the most exergy destruction is related to the evaporator. Two objective functions consist of exergy efficiency and the price of electricity are considered. The decision variables for this optimization are considered as; the number of solar collector panels, the pump, and turbine isentropic efficiencies, and the pressure of condenser and evaporator. The Pareto diagram shows that the exergy efficiency of the system can vary as 7.5 % to 10.5 %, as well as the price of produced electricity can vary from 0.2 to 0.26 to $/kWh. | ||
| کلیدواژهها | ||
| Flat collector؛ Energy؛ Economic؛ Solar | ||
| مراجع | ||
|
[1] Ahmadi A, Ehyaei MA. Development of a Simple Model to Estimate Entropy Generation of Earth. Renewable Energy Research and Application. 2020;1(2):135-41.
[2] Majdi Yazdi MR, Ommi F, Ehyaei MA, Rosen MA. Comparison of gas turbine inlet air cooling systems for several climates in Iran using energy, exergy, economic, and environmental (4E) analyses. Energy Conversion and Management. 2020;216:112944.
[3] Ahmadi A, Esmaeilion F, Esmaeilion A, Ehyaei MA, Silveira JL. Benefits and Limitations of Waste-to-Energy Conversion in Iran. Renewable Energy Research and Application. 2020;1(1):27-45.
[4] Darvish K, Ehyaei MA, Atabi F, Rosen MA. Selection of optimum working fluid for Organic Rankine Cycles by exergy and exergy-economic analyses. Sustainability. 2015;7(1115362-83.
[5] Ehyaei MA, Ahmadi A, El Haj Assad M, Rosen MA. Investigation of an integrated system combining an Organic Rankine Cycle and absorption chiller driven by geothermal energy: Energy, exergy, and economic analyses and optimization. Journal of Cleaner Production. 2020;258:120780.
[6] R. Akbari MAE, R. Shahi Shavvon. Optimization of Solar Rankine Cycle by Exergy Analysis and Genetic Algorithm. International Journal of Energy and Power Engineering. 2019;13(9):630-7.
[7] Li Q, Beier L-J, Tan J, Brown C, Lian B, Zhong W, et al. An integrated, solar-driven membrane distillation system for water purification and energy generation. Applied Energy. 2019;237:534-48.
[8] Zhang H, Guan X, Ding Y, Liu C. Emergy analysis of Organic Rankine Cycle (ORC) for waste heat power generation. Journal of Cleaner Production. 2018;183:1207-15.
[9] Ghasemian E, Ehyaei MA. Evaluation and optimization of organic Rankine cycle (ORC) with algorithms NSGA-II, MOPSO, and MOEA for eight coolant fluids. International Journal of Energy and Environmental Engineering. 2018;9(1):39-57.
[10] Li ZX, Ehyaei MA, Kamran Kasmaei H, Ahmadi A, Costa V. Thermodynamic modeling of a novel solar powered quad generation system to meet electrical and thermal loads of residential building and syngas production. Energy Conversion and Management. 2019;199:111982.
[11] Zeinodini M, Aliehyaei M. Energy, exergy, and economic analysis of a new triple-cycle power generation configuration and selection of the optimal working fluid. Mechanics & Industry. 2019;20(5):501
[12] Ahmadi A, El Haj Assad M, Jamali DH, Kumar R, Li ZX, Salameh T, et al. Applications of geothermal organic Rankine Cycle for electricity production. Journal of Cleaner Production. 2020;274:122950.
[13] Roy JP, Mishra MK, Misra A. Parametric Optimization and Performance Analysis of a Regenerative Organic Rankine Cycle Using Low–Grade Waste Heat for Power Generation. International Journal of Green Energy. 2011;8(2):173-96.
[14] Wang ZQ, Zhou NJ, Guo J, Wang XY. Fluid selection and parametric optimization of organic Rankine cycle using low temperature waste heat. Energy. 2012;40(1):107-15.
[15] Badr O, O'callaghan P, Probert S. Rankine-cycle systems for harnessing power from low-grade energy sources. Applied Energy. 1990;36(4):263-92.
[16] Maizza V, Maizza A. Unconventional working fluids in organic Rankine-cycles for waste energy recovery systems. Applied thermal engineering. 2001;21(3):381-90.
[17] Liu B-T, Chien K-H, Wang C-C. Effect of working fluids on organic Rankine cycle for waste heat recovery. Energy. 2004;29(8):1207-17.
[18] Drescher U, Brüggemann D. Fluid selection for the Organic Rankine Cycle (ORC) in biomass power and heat plants. Applied thermal engineering. 2007;27(1):223-8.
[19] Yousefi M, Ehyaei MA. Feasibility study of using organic Rankine and reciprocating engine systems for supplying demand loads of a residential building. Advances in Building Energy Research. 2019;13(1):32-48.
[20] Heberle F, Preißinger M, Brüggemann D. Zeotropic mixtures as working fluids in Organic Rankine Cycles for low-enthalpy geothermal resources. Renewable Energy. 2012;37(1):364-70.
[21] Li W, Feng X, Yu L, Xu J. Effects of evaporating temperature and internal heat exchanger on organic Rankine cycle. Applied Thermal Engineering. 2011;31(17-1 4014-23.
[22] M.A.Ehyaei HKa. Energy, exergy, and economic analysis of a geothermal powerplant. Advances inGeo-Energy Research. 2018;2(2):190-209.
[23] Quoilin S, Orosz M, Hemond H, Lemort V. Performance and design optimization of a low-cost solar organic Rankine cycle for remote power generation. Solar Energy. 2011;85(5):955-66.
[24] Ben Youssef W, Maatallah T, Menezo C, Ben Nasrallah S. Modeling and optimization of a solar system based on concentrating photovoltaic/thermal collector. Solar Energy. 2018;170:301-13..
[25] Karellas S, Schuster A, Leontaritis A. Influence of supercritical ORC parameters on plate heat exchanger design. Applied Thermal Engineering. 2012;s 33–34:70–6.
[26] Chen H, Goswami D, Rahman M, K. Stefanakos E. Energetic and exergetic analysis of CO2- and R32-based transcritical Rankine cycles for low-grade heat conversion. Applied Energy. 2011;88:2802-8.
[27] Chen H, Goswami D, Rahman M, K. Stefanakos E. A supercritical Rankine cycle using zeotropic mixture working fluids for the conversion of low-grade heat into power. Fuel and Energy Abstracts. 2011;36:549-55.
[28] Wang H, Peterson R, Harada K, Miller E, Ingram-Goble R, Fisher L, et al. Performance of a combined organic Rankine cycle and vapor compression cycle for heat activated cooling. Energy. 2011;36(1):447-58.
[29] Wang M, Wang J, Zhao Y, Zhao P, Dai Y. Thermodynamic analysis and optimization of a solar-driven regenerative organic Rankine cycle (ORC) based on flat-plate solar collectors. Applied Thermal Engineering. 2013;50(1):816-25.
[30] Baccioli A, Antonelli M, Desideri U. Dynamic modeling of a solar ORC with compound parabolic collectors: Annual production and comparison with steady-state simulation. Energy Conversion and Management. 2017;148:708-23.
[31] Bellos E, Tzivanidis C. Investigation of a hybrid ORC driven by waste heat and solar energy. Energy Conversion and Management. 2018;156:427-39.
[32] Saadatfar B, Fakhrai R, Fransson T. Conceptual modeling of nano fluid ORC for solar thermal polygeneration. Energy Procedia. 2014;57:2696-705.
[33] Mokhtari H, Ahmadisedigh H, Ebrahimi I. Comparative 4E analysis for solar desalinated water production by utilizing organic fluid and water. Desalination. 2016;377:108-22.
[34] Zhang Y, Deng S, Zhao L, Ni J, Ma M, Lin S, et al. Clarifying the bifurcation point on Design: A Comparative Analysis between Solar-ORC and ORC-based Solar-CCHP. Energy Procedia. 2017;142:1119-26.
[35] Patel B, Desai NB, Kachhwaha SS, Jain V, Hadia N. Thermo-economic analysis of a novel organic Rankine cycle integrated cascaded vapor compression–absorption system. Journal of Cleaner Production. 2017;154:26-40.
[36] Mohammadi A, Mehrpooya M. Thermodynamic and economic analyses of hydrogen production system using high temperature solid oxide electrolyzer integrated with parabolic trough collector. Journal of Cleaner Production. 2019;212:713-26.
[37] Ashari GR, Ehyaei MA, Mozafari A, Atabi F, Hajidavalloo E, Shalbaf S. Exergy, Economic, and Environmental Analysis of a PEM Fuel Cell Power System to Meet Electrical and Thermal Energy Needs of Residential Buildings. Journal of Fuel Cell Science and Technology. 2012;9(5).
[38] Mohammadnezami MH, Ehyaei MA, Rosen MA, Ahmadi MH. Meeting the Electrical Energy Needs of a Residential Building with a Wind-Photovoltaic Hybrid System. Sustainability. 2015;7(3):2554-69.
[39] Yousefi M, Ehyaei MA, Rosen MA. Optimizing a New Configuration of a Proton Exchange Membrane Fuel Cell Cycle With Burner and Reformer Through a Particle Swarm Optimization Algorithm for Residential Applications. Journal of Electrochemical Energy Conversion and Storage. 2019;16(4).
[40] Aliehyaei M, Atabi F, Khorshidvand M, Rosen MA. Exergy, Economic and Environmental Analysis for Simple and Combined Heat and Power IC Engines. Sustainability. 2015;7(4):4411-24.
[41] Naseri A, Fazlikhani M, Sadeghzadeh M, Naeimi A, Bidi M, Tabatabaei SH. Thermodynamic and Exergy Analyses of a Novel Solar-Powered CO2 Transcritical Power Cycle with Recovery of Cryogenic LNG Using Stirling Engines. Renewable Energy Research and Application. 2020;1(2):175-85.
[42] https://weatherspark.com/y/105125/Average-Weather-in-Tehran-Iran-Year-Round [Access 2019].
[43] Kalogirou SA. Solar thermal collectors and applications. Progress in Energy and Combustion Science. 2004;30(3):231-95.
[44] Mokhtari H, Ahmadisedigh H, Ameri M. The optimal design and 4E analysis of double pressure HRSG utilizing steam injection for Damavand power plant. Energy. 2017;118:399-413.
[45] Bergman TL, Incropera FP, Lavine AS, Dewitt DP. Introduction to heat transfer: John Wiley & Sons, 2011.
[46] Hajabdollahi H. Evaluation of cooling and thermal energy storage tanks in optimization of multi-generation system. Journal of Energy Storage. 2015;4:1-13.
[47] Cengel YA, Boles MA. Thermodynamics: an engineering approach. Sea. 2002;1000:8862.
[48] Mozafari A, Ehyaei MA. Effects of Regeneration Heat Exchanger on Entropy, Electricity Cost, and Environmental Pollution Produced by Micro Gas Turbine System. International Journal of Green Energy. 2012;9(1):51-70.
[49] Asgari E, Ehyaei MA. Exergy analysis and optimisation of a wind turbine using genetic and searching algorithms. International Journal of Exergy. 2015;16(3):293-314.
[50] Shaygan M, Ehyaei MA, Ahmadi A, Assad MEH, Silveira JL. Energy, exergy, advanced exergy and economic analyses of hybrid polymer electrolyte membrane (PEM) fuel cell and photovoltaic cells to produce hydrogen and electricity. Journal of Cleaner Production. 2019;234:1082-93.
[51] Ehyaei MA, Ahmadi A, Assad MEH, Hachicha AA, Said Z. Energy, exergy and economic analyses for the selection of working fluid and metal oxide nanofluids in a parabolic trough collector. Solar Energy. 2019;187:175-84.
[52] Frangopoulos CA. Thermo-economic functional analysis and optimization. Energy. 1987;12(7):563-71.
[53] Alshammari F, Karvountzis-Kontakiotis A, Pesyridis A, Usman M. Expander Technologies for Automotive Engine Organic Rankine Cycle Applications. Energies. 2018;11(7):1905.
[54] Lecompte S, Huisseune H, Van den Broek M, De Schampheleire S, De Paepe M. Part load based thermo-economic optimization of the Organic Rankine Cycle (ORC) applied to a combined heat and power (CHP) system. Applied Energy. 2013;111:871-81.
[55] Quoilin S, Declaye S, Tchanche BF, Lemort V. Thermo-economic optimization of waste heat recovery Organic Rankine Cycles. Applied thermal engineering. 2011;31(14-15):2885-93.
[56] Brown JS. HFOs: new, low global warming potential refrigerants. Ashrae Journal. 2009;51(8):22-8.
[57] Eberhart R, Kennedy J. A new optimizer using particle swarm theory. Conference A new optimizer using particle swarm theory. IEEE, p. 39-43.
[58] Eberhart RC, Shi Y. Comparison between genetic algorithms and particle swarm optimization. Conference Comparison between genetic algorithms and particle swarm optimization. Springer, p. 611-6.
[59] Coello CAC, Pulido GT, Lechuga MS. Handling multiple objectives with particle swarm optimization. IEEE Transactions on evolutionary computation. 2004;8(3):256-79.
[60] Shirmohammadi R, Ghorbani B, Hamedi M, Hamedi M-H, Romeo LM. Optimization of mixed refrigerant systems in low temperature applications by means of group method of data handling (GMDH). Journal of Natural Gas Science and Engineering. 2015;26:303-12.
[61] Clerc M. Particle-Swarm Optimization (iste ed.). London; 2006.
[62] Safarian S, Aramoun F. Energy and exergy assessments of modified Organic Rankine Cycles (ORCs). Energy Reports. 2015;1:1-7.
| ||
|
آمار تعداد مشاهده مقاله: 1,604 تعداد دریافت فایل اصل مقاله: 961 |
||