Soil Stabilization using Ceramic Waste: an Experimental Study | ||
| Journal of Mining and Environment | ||
| مقاله 4، دوره 14، شماره 1، فروردین 2023، صفحه 47-65 اصل مقاله (12.16 M) | ||
| نوع مقاله: Original Research Paper | ||
| شناسه دیجیتال (DOI): 10.22044/jme.2023.12442.2259 | ||
| نویسندگان | ||
| Pankaj Rathore* ؛ Suresh Kumar Tiwari | ||
| Civil Engineering Department, Malaviya National Institute of Technology, Jaipur, India | ||
| چکیده | ||
| The main aim of this experimental analysis is to understand the effectiveness of ceramic waste (CW) in stabilizing the clayey soil. The effect of adding various CW percentages (5%, 10%, 15%, 20%, 25%, and 30%) on the geotechnical properties of clayey soil is evaluated by performing a series of laboratory tests like the Atterberg’s limit test, compaction test, unconfined compressive strength (UCS) test, California bearing ratio (CBR) test, and swelling pressure test. Micro-structural analysis including scanning electron microscopy (SEM), energy dispersive spectroscopy (EDS), X-ray diffraction (XRD), and Fourier transform-infrared (FT-IR) spectroscopy are carried out on untreated and treated clay-ceramic composites. The results obtained indicate that the incorporation of 30% ceramic waste in clay soil increase the maximum dry unit weight (γmax) from 17.20 kN/m3 (CL + 0% CW) to 18.25 kN/m3 (CL + 30% CW). The unconfined compressive strength of clayey soil increases with the addition of ceramic waste. A maximum UCS of 217 kPa is obtained with 25% ceramic content, beyond which it starts decreasing. Similarly, increasing trend in CBR results is observed with an increase in the ceramic waste content. The increment in CBR is approximately 152% (unsoaked condition) and 142% (soaked condition). At the same time, the addition of ceramic waste in clay soil reduces the Atterberg limits, optimum water content (ωopt), and swelling pressure. “It can be concluded from the experimental study that CW can be used as a sustainable alternative soil stabilizer. | ||
| کلیدواژهها | ||
| Ceramic waste؛ Stabilization؛ Maximum dry unit weight؛ UCS؛ Clayey soil | ||
| مراجع | ||
|
[1]. Sabtan, A.A. (2005). Geotechnical properties of expansive clay shale in Tabuk, Saudi Arabia. Journal of Asian Earth Sciences, 25(5), 747-757.
[2]. Yadav, J. S. and Tiwari, S. K. (2018). Evaluation of the strength characteristics of cement-stabilized clay–crumb rubber mixtures for its sustainable use in geotechnical applications. Environment, Development and Sustainability, 20(5), 1961-1985.
[3]. Katti, R.K. (1978). Search for solutions to problems in black cotton soils. Bombay: Indian Institute of Technology.
[4]. Chen, J.A. and Uloko, J. O. (2017). Comparative Study of Effect of Waste Ceramic and Marble Dusts on Geotechnical Properties of Expansive Soil. Electronic Journal of Geotechnical Engineering, 22, 5073-5086.
[5]. Al-Baidhani, A.F. and Al-Taie, A.J. (2020). Recycled crushed ceramic rubble for improving highly expansive soil. Transportation Infrastructure Geotechnology, 7(3), 426-444.
[6]. Sharma, R.K. (2020). Utilization of fly ash and waste ceramic in improving characteristics of clayey soil: A Laboratory Study. Geotechnical and Geological Engineering, 38(5), 5327-5340.
[7]. Pourakbar, S., Asadi, A., Huat, B.B., and Fasihnikoutalab, M.H. (2015). Stabilization of clayey soil using ultrafine palm oil fuel ash (POFA) and cement. Transportation Geotechnics, 3, 24-35.
[8]. Al-Bared, M.A.M., Harahap, I. S. H., and Marto, A. (2018). Sustainable strength improvement of soft clay stabilized with two sizes of recycled additive. GEOMATE Journal, 15(51), 39-46.
[9]. Harichane, K., Ghrici, M., Kenai, S., and Grine, K. (2011). Use of natural pozzolana and lime for stabilization of cohesive soils. Geotechnical and geological engineering, 29(5), 759-769.
[10]. Radhakrishnan, G., Kumar, M.A., and Raju, G.V.R.P. (2014). Swelling properties of expansive soils treated with chemicals and fly ash. Am J Eng Res, 3(4), 245-250.
[11]. Marto, A., Aziz, N., Jahidin, M. R., Yunus, N.Z.M., Kasim, F., and Tan, C.S. (2015). Soft soil improvement using chemical-rubber chips mixture. Jurnal Teknologi, 76(2).
[12]. Mekhilef, S., Saidur, R., and Kamalisarvestani, M. (2012). Effect of dust, humidity and air velocity on efficiency of photovoltaic cells. Renewable and sustainable energy reviews, 16(5), 2920-2925.
[13]. Yilmaz, Y.Ü.K.S.E.L. (2015). Compaction and strength characteristics of fly ash and fiber amended clayey soil. Engineering Geology, 188, 168-177.
[14]. Kamaraj, N., Janani, V., Ravichandran, P.T., Nigitha, D., and Priyanka, K. (2016). Study on improvement of soil behaviour by bio-stabilsation method. Indian J. Sci. Technol, 9(33), 1-5.
[15]. Kim, D. and Park, K. (2013). An environmentally friendly soil improvement technology with microorganism. International Journal of Railway, 6(3), 90-94.
[16]. Jayasekera, S. and Hall, S. (2007). Modification of the properties of salt affected soils using electrochemical treatments. Geotechnical and Geological Engineering, 25(1), 1-10.
[17]. Nordin, N.S., Tajudin, S.A., and Kadir, A.A. (2013). Stabilisation of soft soil using electrokinetic stabilisation method. International Journal of Zero Waste Generation, 1(1), 5-12.
[18]. Ahmad, K.B., Taha, M.R., and Kassim, K.A. (2011). Electrokinetic treatment on a tropical residual soil. Proceedings of the Institution of Civil Engineers-Ground Improvement, 164(1), 3-13.
[19]. Etim, R.K., Attah, I.C., Ekpo, D.U., and Usanga, I.N. (2022). Evaluation on stabilization role of lime and cement in expansive black clay–oyster shell ash composite. Transportation Infrastructure Geotechnology, 9(6), 729-763.
[20]. Arora, S. and Aydilek, A.H. (2005). Class F fly-ash-amended soils as highway base materials. Journal of materials in civil engineering, 17(6), 640-649.
[21]. Kumar, A. and Gupta, D. (2016). Behavior of cement-stabilized fiber-reinforced pond ash, rice husk ash–soil mixtures. Geotextiles and Geomembranes, 44(3), 466-474..
[22]. Liu, L., Deng, T., Deng, Y., Zhan, L., Horpibulsuk, S., and Wang, Q. (2022). Stabilization nature and unified strength characterization for cement-based stabilized soils. Construction and Building Materials, 336, 127544.
[23]. Ai-sharif, M.M. and Attom, M.F. (2014). A geoenvironmental application of burned wastewater sludge ash in soil stabilization. Environmental Earth Sciences, 71(5), 2453-2463.
[24]. Hassan, H.J.A., Rasul, J., and Samin, M. (2021). Effects of plastic waste materials on geotechnical properties of clayey soil. Transportation Infrastructure Geotechnology, 8(3), 390-413.
[25]. Bhardwaj, A., Sharma, R.K., and Sharma, A. (2021). Stabilization of clayey soil using waste foundry sand and molasses. In Sustainable Development Through Engineering Innovations (pp. 641-649). Springer, Singapore.
[26]. Onakunle, O., Omole, D.O., and Ogbiye, A.S. (2020). Stabilization of lateritic soil from Agbara Nigeria with ceramic waste dust stabilization of lateritic soil from Agbara Nigeria with ceramic waste dust. Cogent Engineering, 6(1).
[27]. Cabalar, A.F., Hassan, D.I., and Abdulnafaa, M.D. (2017). Use of waste ceramic tiles for road pavement subgrade. Road Materials and Pavement Design, 18(4), 882-896.
[28]. Senthamarai, R.M. and Manoharan, P.D. (2005). Concrete with ceramic waste aggregate. Cement and concrete composites, 27(9-10), 910-913.
[29]. Muthukannan, M. and Ganesh, A.S.C. (2019). The environmental impact caused by the ceramic industries and assessment methodologies. International Journal for Quality Research, 13(2), 315.
[30]. Status Quo and Outlook (2022). Indian Ceramics Industry. Messe Muenchen India & EAC International Consulting.
[31]. Meepon, I., Voottipruex, P., and Teerawattanasuk, C. (2019). Marginal lateritic soil treated using ceramic waste for rural road application. GEOMATE Journal, 16(53), 70-77.
[32]. Sabat, A.K. (2012). Stabilization of expansive soil using waste ceramic dust. Electronic Journal of Geotechnical Engineering, 17(Z), 3915-3926.
[33]. Rani, T.G., Shivanarayana, C., Prasad, D., and Raju, G.V.R. (2014). Strength behaviour of expansive soil treated with tile waste. Int J Eng Res Dev, 10(12), 52-57.
[34]. Neeladharan, C., Vinitha, V., Priya, B., and Saranya, S. (2017). Stabilisation of soil by using tiles waste with sodium hydroxide as binder. Int J Innov Res Sci Eng Technol, 6(4), 6762-6768.
[35]. Hossain, M.A., Afride, M.R., and Nayem, N.H. (2019). Improvement of strength and consolidation properties of clayey soil using ceramic dust. American Journal of Civil Engineering, 7(2), 41-46.
[36]. Rajoria, V. and Kaur, S. (2015). Effect of polymer stabilizer on the geotechnical properties of black cotton soil. In Proc. Indian Geotech. Conf.
[37]. Santos, L.F., Silva, A.C.L.D., and Frota, C.A.D. (2019). Shear strength of a typical soil from Manaus, Brazil, stabilized with ceramic residue additive. Matéria (Rio de Janeiro), 24.
[38]. Deboucha, S., Sail, Y., and Ziani, H. (2020). Effects of ceramic waste, marble dust, and cement in pavement sub-base layer. Geotechnical and Geological Engineering, 38(3), 3331-3340.
[39]. Sankar, A. and Soorya, S.R. (2020) Improvement of Strength of Clayey Soil Using Ceramic Dust. International Journal of Scientific Research and Engineering Development-– Volume 3.
[40]. Mahmud, M.B. (2021). Effect of Ceramic Waste on Geotechnical Properties of Cement Stabilized Clay Soil (Doctoral dissertation).
[41]. Singh, B., Kumar, A., and Sharma, R.K. (2014). Effect of waste materials on strength characteristics of local clay. International Journal of Civil Engineering Research, 5(1), 61-68.
[42]. Panwar, K. and Ameta, N.K. (2016). Stabilization of fine sand with ceramic tiles waste as admixture for construction of embankment. AJER, 5(8), 206-212.
[43]. Gupta, A. and Ameta, N.K. (2016). Fine sand stabilization using sanitary ware waste as admixture for design of flexible pavement in construction of roads. AJER, 5(8), 186-191.
[44]. Okeke, C.A. (2020). Engineering behaviour of lime-and waste ceramic dust-stabilized expansive soil under continuous leaching. Bulletin of Engineering Geology and the Environment, 79(4), 2169-2185.
[45]. Moreira, E.B., Baldovino, J.A., Rose, J.L., and dos Santos Izzo, R.L. (2019). Effects of porosity, dry unit weight, cement content and void/cement ratio on unconfined compressive strength of roof tile waste-silty soil mixtures. Journal of Rock Mechanics and Geotechnical Engineering, 11(2), 369-378.
[46]. Sharma, R.K. (2020). Utilization of fly ash and waste ceramic in improving characteristics of clayey soil: A Laboratory Study. Geotechnical and Geological Engineering, 38(5), 5327-5340.
[47]. Adeboje, A.O., Kupolati, W.K., Sadiku, E.R., Ndambuki, J.M., Owolabi, A.O., and Kambole, C. (2020). Stabilisation of lateritic soil with pulverised ceramic waste for road construction. International Journal of Environmental Engineering, 10(3), 221-242.
[48]. Balegh, B., Sellaf, H., and Hadjmostefa, A. (2020). Effect of ceramic waste on mechanical and geotechnical properties of tuff treated by cement. Case Studies in Construction Materials, 13, e00368.
[49]. Beyene, A., Tesfaye, Y., Tsige, D., Sorsa, A., Wedajo, T., Tesema, N., and Mekuria, G. (2022). Experimental study on potential suitability of natural lime and waste ceramic dust in modifying properties of highly plastic clay. Heliyon, 8(10), e10993.
[50]. Dhar, S. and Hussain, M. (2019). The strength and microstructural behavior of lime stabilized subgrade soil in road construction. International Journal of Geotechnical Engineering.
[51]. Jain, A., Chaudhary, S., and Gupta, R. (2022). Mechanical and microstructural characterization of fly ash blended self-compacting concrete containing granite waste. Construction and Building Materials, 314, 125480.
[52]. Siddique, S., Shrivastava, S., and Chaudhary, S. (2018). Influence of ceramic waste as fine aggregate in concrete: Pozzolanic, XRD, FT-IR, and NMR investigations. Journal of Materials in Civil Engineering, 30(9), 04018227.
[53]. Al-Bared, M.A.M., Marto, A., Latifi, N., and Horpibulsuk, S. (2018). Sustainable improvement of marine clay using recycled blended tiles. Geotechnical and Geological Engineering, 36(5), 3135-3147.
[54]. Tang, C., Shi, B., Gao, W., Chen, F., and Cai, Y. (2007). Strength and mechanical behavior of short polypropylene fiber reinforced and cement stabilized clayey soil. Geotextiles and Geomembranes, 25(3), 194-202.
[55]. Yadav, J.S. and Tiwari, S.K. (2016). Behaviour of cement stabilized treated coir fibre-reinforced clay-pond ash mixtures. Journal of Building Engineering, 8, 131-140.
[56]. Pokharel, B. and Siddiqua, S. (2021). Effect of calcium bentonite clay and fly ash on the stabilization of organic soil from Alberta, Canada. Engineering Geology, 293, 106291.
[57]. Jha, A.K. and Sivapullaiah, P.V. (2015). Mechanism of improvement in the strength and volume change behavior of lime stabilized soil. Engineering Geology, 198, 53-64.
[58]. Peyne, J., Gautron, J., Doudeau, J., Joussein, E., and Rossignol, S. (2017). Influence of calcium addition on calcined brick clay based geopolymers: A thermal and FTIR spectroscopy study. Construction and building materials, 152, 794-803.
[59]. El-Mahllawy, M.S., Kandeel, A.M., Abdel Latif, M.L., and El Nagar, A.M. (2018). The feasibility of using marble cutting waste in a sustainable building clay industry. Recycling, 3(3), 39.
[60]. Tinti, A., Tugnoli, V., Bonora, S., and Francioso, O. (2015). Recent applications of vibrational mid-Infrared (IR) spectroscopy for studying soil components: a review. Journal of Central European Agriculture, 16(1), 0-0.
[61]. Latifi, N., Rashid, A.S.A., Siddiqua, S., and Horpibulsuk, S. (2015). Micro-structural analysis of strength development in low-and high swelling clays stabilized with magnesium chloride solution—A green soil stabilizer. Applied Clay Science, 118, 195-206.
[62]. Tawalare, A. and Raju, K. V. (2016). Pavement performance index for Indian rural roads. Perspectives in Science, 8, 447-451.
[63]. Congress, I.R. (2001). Guidelines for the design of flexible pavements. Indian code of practice, IRC, 37.
[64]. IRC, S. (2002). SP 20-2002. In Rural road manual, Indian Road Congress, New Delhi, India. | ||
|
آمار تعداد مشاهده مقاله: 536 تعداد دریافت فایل اصل مقاله: 1,096 |
||