Experimental Analysis of a Silica Gel–Water Adsorption Cooling System with Integrated Chamber for Adsorbent Bed and the Condenser | ||
| Renewable Energy Research and Applications | ||
| دوره 6، شماره 2، مهر 2025، صفحه 259-268 اصل مقاله (559.77 K) | ||
| نوع مقاله: Original Article | ||
| شناسه دیجیتال (DOI): 10.22044/rera.2025.16116.1418 | ||
| نویسندگان | ||
| Ali Fahim؛ Ahmad Nazari؛ mohammad Zamen* ؛ Amirreza Salamat Asrami | ||
| Faculty of Mechanical Engineering, Shahrood University of Technology, Shahrood, Iran. | ||
| چکیده | ||
| A significant portion of energy consumption, particularly during the summer, is attributed to cooling demands in buildings. The most common methods for providing cooling are vapor compression and absorption refrigeration systems. However, in recent years, alternative methods based on adsorption have been explored, and some systems have even reached the commercial market. In Iran, however, such systems have only been investigated at the laboratory level. The goal of this study experimental evaluation of a silica gel–water adsorption cooling system. The constructed system included an adsorbent bed filled with silica gel, a condenser, an evaporator, a heating unit, and a cooling water circulation system. A key feature of this design is the use of a chamber for both the adsorbent bed and the condenser which makes the system simpler. After construction, the system was tested and its performance data were collected. The cooling energy produced at the end of each cycle was measured based on the temperature change in the evaporator. According to the results, the cooling energy per cycle ranged between 1.3 and 1.8 kWh, with a maximum heating energy requirement of approximately 1.8 kWh. Based on various experimental runs, the coefficient of performance (COP) of the system was calculated to be in the range of 0.035 to 0.048. The use of an integrated chamber simplifies the system, but it results in reduced performance. | ||
| کلیدواژهها | ||
| Refrigeration؛ Adsorption؛ Silica Gel؛ Coefficient of Performance | ||
| مراجع | ||
|
[1] Arabkoohsar, A., & Sadi, M. (2020). Technical comparison of different solar-powered absorption chiller designs for co-supply of heat and cold networks. Energy Conversion and Management, 206, 112343.
[2] Liu, Z., N. Xie, and S. Yang, Thermodynamic and parametric analysis of a coupled LiBr/H2O absorption chiller/Kalina cycle for cascade utilization of low-grade waste heat. Energy Conversion and Management, 2020. 205: p. 112370.
[3] Bellos, E., Tzivanidis, C., Symeou, C., & Antonopoulos, K. A. (2017). Energetic, exergetic and financial evaluation of a solar driven absorption chiller–A dynamic approach. Energy conversion and management, 137, 34-48.
[4] Mirzaee, M., Zare, R., Sadeghzadeh, M., Maddah, H., Ahmadi, M. H., Acıkkalp, E., & Chen, L. (2019). Thermodynamic analyses of different scenarios in a CCHP system with micro turbine–Absorption chiller, and heat exchanger. Energy Conversion and Management, 198, 111919.
[5] Rezk, A. R. M. (2012). Theoretical and experimental investigation of silica gel/water adsorption refrigeration systems (Doctoral dissertation, University of Birmingham).
[6] Younes, M.M., et al., Characterization of silica gel-based composites for adsorption cooling applications. International Journal of Refrigeration, 2020. 118: p. 345-353.
[7] Alonso, S., Morán, A., Pérez, D., Reguera, P., Díaz, I., & Domínguez, M. (2019, May). Virtual sensor based on a deep learning approach for estimating efficiency in chillers. In International Conference on Engineering Applications of Neural Networks (pp. 307-319). Cham: Springer International Publishing.
[8] Manila, M. R., Mitra, S., & Dutta, P. (2020). Studies on dynamics of two-stage air cooled water/silica gel adsorption system. Applied Thermal Engineering, 178, 115552.
[9] Sztekler, K., Kalawa, W., Mlonka-Medrala, A., Nowak, W., Mika, Ł., Krzywanski, J., ... & Debniak, M. (2020). The effect of adhesive additives on silica gel water sorption properties. Entropy, 22(3), 327.
[10] Lee, J. G., Bae, K. J., & Kwon, O. K. (2020). Performance investigation of a two-bed type adsorption chiller with various adsorbents. Energies, 13(10), 2553.
[11] Liu, Y. M., Yuan, Z. X., Wen, X., & Du, C. X. (2021). Evaluation on performance of solar adsorption cooling of silica gel and SAPO-34 zeolite. Applied Thermal Engineering, 182, 116019.
[12] Najeh, G., Gabsi, S., El Ganaoui, M., & Benelmir, R. (2021). Experimental Analysis of a Solar Adsorption System Refrigeration Cycle with Silica-Gel/Water Pair. Journal of Fundamentals of Renewable Energy and Applications, 11(1).
[13] Di, J., Wu, J. Y., Xia, Z. Z., & Wang, R. Z. (2007). Theoretical and experimental study on characteristics of a novel silica gel–water chiller under the conditions of variable heat source temperature. International Journal of Refrigeration, 30(3), 515-526.
[14] Núñez, T., Mittelbach, W., & Henning, H. M. (2007). Development of an adsorption chiller and heat pump for domestic heating and air-conditioning applications. Applied Thermal Engineering, 27(13), 2205-2212.
[15] Chen, C. J., Wang, R. Z., Xia, Z. Z., Kiplagat, J. K., & Lu, Z. S. (2010). Study on a compact silica gel–water adsorption chiller without vacuum valves: design and experimental study. Applied Energy, 87(8), 2673-2681.
[16] Chorowski, M., & Pyrka, P. (2015). Modelling and experimental investigation of an adsorption chiller using low-temperature heat from cogeneration. Energy, 92, 221-229.
[17] Pan, Q., Peng, J., & Wang, R. (2019). Experimental study of an adsorption chiller for extra low temperature waste heat utilization. Applied Thermal Engineering, 163, 114341.
[18] Chorowski, M. and P. Pyrka, Modelling and experimental investigation of an adsorption chiller using low-temperature heat from cogeneration. Energy, 2015. 92: p. 221-229.
[19] Sah, R. P., Sur, A., Sarma, N. D., & Chaurasiya, S. P. (2024). Comparative Study on Performances of Waste Heat Driven Adsorption Cooling System Using Silica Gel/Methanol and Silica Gel/Water Working Pair. Journal Européen des Systèmes Automatisés, 57(6).
[20] Du, S., Cui, Z., Wang, R. Z., Wang, H., & Pan, Q. (2024). Development and experimental study of a compact silica gel-water adsorption chiller for waste heat driven cooling in data centers. Energy Conversion and Management, 300, 117985.
[21] El-Ghetany, H. H., Omara, M. A., Abdelhady, R. G., & Abdelaziz, G. B. (2023). Design of silica gel/water adsorption chiller powered by solar energy for air conditioning applications. Journal of Energy Storage, 63, 107055. | ||
|
آمار تعداد مشاهده مقاله: 219 تعداد دریافت فایل اصل مقاله: 154 |
||